Battery Supply-Delivery-Installation
Call or Text Us: 619-315-5604

Golf Cart Battery

Golf Cart Battery Made Simple.

Call Us Today to Schedule Delivery and Installation for Your Golf Cart Battery (619) 448-5323

Save time and energy by letting Deep Cycle Battery San Diego deliver and install your golf cart batteries.

Know Your Golf Cart Battery

A golf cart battery is used to power an electric golf cart or utility vehicle and needs to be maintained at minimum monthly. Distilled water is required to refill the deep cycle batteries and only fill batteries that are fully charged.

golf cart battery water

How Golf Cart Batteries are Wired Together

A golf cart operates by a “bank” of individual golf cart batteries wired together in series to achieve the voltage the golf cart requires to operate.
When batterie are wired in series, the voltage of each battery is added together but the capacity remains the same.
Battery Series Example: Six Trojan T-105 (225 ah each)  in series will equal a nominal voltage of 36 volts total but only 225 ah.  The correct battery pack voltage at full charge will be 39.6VDC. The charger should charge 36 volt bank at about 42 volts.

How to Measure a Golf Cart Batteries Health

The most cost effective way to test the health of your golf cart batteries is with a battery hydrometer.
A battery hydrometer will measure the specific gravity of the electrolyte inside. To perform a battery hydrometer test, first fully charge the batteries and record the specific gravity (sg) of every cell .
A healthy battery will have three cells that have sg at 1.256 or higher.  If a cell is lagging behind sometimes a temporary overcharge called EQ will remedy.
Note as a battery ages, the sg values will decrease and recharging time will increase.  Don’t waste money on chemical gimick’s that promise to rejuvenate tired batteries.

Golf Cart Battery

What to Know When Calling on Golf Batteries

Often when you call a battery shop about purchasing golf cart batteries, they will ask you what golf cart you own in terms of it’s voltage, ie 36 or 48 volt golf cart. Tip, the golf cart voltage is the same as the charger you are using to charge the batteries.
Most common early model EZGO golf carts were 36 volt and later model EZGO RXV are 48 volt.

Typically in San Diego, you will find a Trojan brand 6 volt golf cart battery under the seat of your 36 volt EZGO golf cart.     Trojan golf cart batteryOther times you may see a Costco brand golf cart battery because they are inexpensive and low end.

EZGO RXV are interesting because they decided to operate with four large (80 lbs each) 12 volt deep cycle batteries.  These batteries are usually 150 amp hours each wired in series to equal 48 volt but only a sum total of 150 amp hours.  Link to What are Battery Amp Hours?
Common 12 volt 150 ah RXV golf cart batteries are Trojan T1275 and Crown CRGC150
Trojan golf cart battery
Club Car golf carts are usually 48 volt using six 8 volt deep cycle golf cart batteries wired in series with an average of 150 ah. The 48 volt carts will have more torque and climb hills better than 36 volt carts but have less range.  If you would like to increase the speed of your 48 volt golf  cart, look into upgrading the speed controller and possibly installing a higher horsepower motor. Our friend Matt at Ramona Golf Carts can help. Call him directly at (619) 727-0613

Club Car Precedent models are also 48 volt carts but like the EZGO RXV use four 12 volt deep cycle batteries with a minimum of 140-150 ah each.
The RXV and Precedent model golf carts are frequently repurposed for street because their top speed can be tuned.

72 Volt Golf Carts are categorized as EV or NEV for electric vehicle and neighborhood electric vehicle.
These batteries are different from traditional golf cart batteries and are significantly more expensive.

Our Golf Cart Battery Service

If you need testing of your golf cart batteries, give us a call today.
If you need free local delivery and with assisted replacement, we can help.
We will remove the old batteries, install new batteries, check the interconnector battery cables and measure the output voltage from the battery charger.  If a new golf cart battery charger is needed, we stock Quick Charge chargers because they are the best and batteries last longer with them.

Golf Cart Battery Tip

The golf battery and a good golf cart charger are mutually exclusive like a plant and sunlight.
A good charger provides the base for well-performing lead acid golf cart batteries.

Charge often! Lead acid batteries must always be stored at full state-of-charge. Low state of charge causes sulfation, a condition that robs the lead battery of performance. Lead acid has a moderate life span that can be extended with good charging and is not subject to memory.

Deep Cycle Battery San Diego

We Deliver and offer Golf Cart Battery Installation Available Too!
Deep Cycle Battery San Diego Has Full Stock on 6 Volt – 8 Volt – 12 Volt Golf Cart Batteries in San Diego. Call Us Today to Schedule Free Local Delivery for Your Golf Cart Battery Replacement.

All Major Brands of Golf Cart Batteries Available.  Golf Cart Batteries Are Rated Good – Better and Best Based on How They Are Made and Materials Used

Golf Cart Battery San Diego Brands Available at Deep Cycle Battery San Diego

Trojan Battery Golf Cart Battery Models in Stock are T-105, T-875, T-1275 & Pacer
Crown Battery Golf Cart Battery Models in Stock are CR205, CR220, CR235, CR260, CR150, CRGC150

Maintenance Free Golf Cart Batteries

Non traditional maintenance free AGM deep cycle golf cart batteries are used in sensitive applications that prohibit chance of battery acid spilling on the ground.  For this, an absorbed glass mat battery is perfect because the sulfuric acid is immobilized inside the fiberglass mat between the battery plates making the battery spill-proof.  Call us to learn more (619) 315-5604

 Golf Cart Battery Delivery and Installation

Rapid scheduling is available for your golf cart battery needs. Call or Text Us Today at (619) 315-5604

 golf cart battery

 For Battery Pricing, Select The Golf Cart Battery You Want by Golf Cart Models

The EZGO 36 volt golf cart using six 6 volt batteries can be viewed by clicking on golf cart image below.

36 Volt EZGO Golf Cart Battery San Diego (Link for Prices)

golf cart batterygolf cart batterygolf cart battery

36 Volt EZGO Golf Cart Battery San Diego (Link for Prices)

The EZGO RXV 48 volt golf cart using four 12 volt batteries can be viewed by clicking on golf cart image below.

48 Volt EZGO RXV Golf Cart Battery San Diego (Link for Prices)

golf cart batterygolf cart batterygolf cart battery

48 Volt EZGO RXV Golf Cart Battery San Diego (Link for Prices)

The Club Car 48 volt golf cart using four 12 volt batteries can be viewed by clicking on golf cart image below.

48 Volt Club Car Precedent Golf Cart Battery San Diego (Link for Prices)

golf cart batterygolf cart batteryGolf Cart Battery San Diego

48 Volt Club Car Precedent Golf Cart Battery San Diego (Link for Prices)

The early model Western 36 volt golf cart using six 6 volt batteries can be viewed by clicking on golf cart image below.

36 Volt Western Golf Cart Battery San Diego (Link for Prices)

golf cart batterygolf cart batterygolf cart battery

36 Volt Western Golf Cart Battery San Diego (Link for Prices)

The Club Car 48 volt golf cart using six 8 volt batteries can be viewed by clicking on golf cart image below.

48 Volt Club Car Golf Cart Battery San Diego (Link for Prices)

golf cart batterygolf cart batterygolf cart battery

48 Volt Club Car Golf Cart Battery San Diego (Link for Prices)

The Yamaha 48 volt golf cart using six 8 volt batteries can be viewed by clicking on golf cart image below.

48 Volt Yamaha Golf Cart Battery San Diego Using Six 8V Batteries (Link for Prices)

golf cart batterygolf cart batterygolf cart battery

48 Volt Yamaha Golf Cart Battery San Diego Using Six 8V Batteries (Link for Prices)

The Yamaha 48 volt golf cart using four 12 volt batteries can be viewed by clicking on golf cart image below.

48 Volt Yamaha Golf Cart Battery San Diego Using Four 12V Batteries (Link for Prices)

golf cart batterygolf cart batterygolf cart battery

48 Volt Yamaha Golf Cart Battery San Diego Using Four 12V Batteries (Link for Prices)

The Taylor Dunn utility cart using six heavy duty 6 volt batteries can be viewed by clicking on golf cart image below.

36 Volt Taylor Dunn Utility Golf Cart Battery San Diego (Link for Prices)

golf cart batterygolf cart batterygolf cart battery

36 Volt Taylor Dunn Utility Golf Cart Battery San Diego (Link for Prices)

 

 

48 Volt Zone Golf Cart Battery San Diego Using Eight 6V Batteries

golf cart batterygolf cart battery san diegoGolf Cart Battery San Diego

48 Volt Zone Golf Cart Battery San Diego Using Eight 6V Batteries

The Street Legal GEM Car using six 12 volt deep cycle batteries can be viewed by clicking the EV image below.

72 Volt GEM Car Battery San Diego Using Six 12V Batteries (Link for Prices)

golf cart batterygolf cart battery san diegoGolf Cart Battery San Diego

72 Volt GEM Car Battery San Diego Using Six 12V Batteries (Link for Prices)

72 Volt Ford Think Battery San Diego Using Six 12V Gel Batteries

golf cart batterygolf cart battery san diegoGolf Cart Battery San Diego

72 Volt Ford Think Battery San Diego Using Six 12V Gel Batteries

Highly Recommended Golf Cart Battery Charger for Sale
golf cart battery

Visit our Golf Cart Battery Charger link to see on-board and portable battery chargers available.
Quick Charge battery chargers are designed to charge and maintain the golf cart battery pack.

How to Tell if a Golf Cart Battery is Fully Charged

Using a voltmeter at the individual batteries terminals, measure and record the open circuit voltage.  Note, the golf battery must have been off the charger or load for 24 hours for accuracy. 

Battery Voltage vs. State of Charge for 12 volt Golf Cart Batteries ie RXV, Precedent, Yamaha models.

% Charged

Flooded Golf Cart Battery 

100

12.60v or higher

75

12.40v

50

12.20v

25

12.00v

0

11.80v

Open Circuit Voltage vs. State of Charge Comparison*

NOTE: Divide values in half in using 6-volt batteries. Accurate O.C.V. measurement can only be determined after the battery has been off charge or load for 24 hours

Battery Voltage vs. State of Charge for 12 volt Golf Cart Batteries ie 36 volt models.

% Charged

Flooded Golf Cart Battery 

100

6.30v or higher

75

6.20v

50

6.10v

25

6.0v

0

5.90v

Overcharging vs. Undercharging Golf Batteries

Oddly, undercharging, not overcharging, is the biggest killer for golf batteries.
The flooded lead acid battery grid is a lead alloy that uses antimony to help lock the active material onto the plate.  But, if the battery is chronically left is a less than full state of charge, the lead sulfate PBSO4 will compound, harden and make the battery resistant to re-charging.

Replacement Golf Cart Battery Cable for Sale

Upgrade the weak factory 6 ga to 4 ga and even 2 ga welding cable made in house.

Golf Cart Battery Cable 4 gauge golf cart battery

6 volt for 36 volt Carts (click to visit page)

8 volt for 48 volt Carts (click to visit page)

12 volt for 48 volt Carts (click to visit page)

12 volt for 72 volt Electric Cars (click to visit page)

  • A Good Golf Cart Battery Can Last 3 Years With Regular Maintenance and Care
  • A Better Golf Cart Battery Can Last 4-5 Years With Regular Maintenance and Care
  • And Best Golf Cart Batteries Can Last 5-6 Years With Regular Maintenance and Care

Golf carts & electric vehicles run on 6 volt, 8 volt or 12 volt deep cycle batteries

Q: How do I know the voltage of the battery I need for my golf cart?

A: Count the number of caps or cells on top of the battery and multiply by 2.  Each cap or cell is approx 2 volts.  # of cells x 2 volts equal the voltage each battery has , example, three cells=6 volt battery
Multiply the number of batteries x’s the voltage of each battery = the electric vehicle’s total system voltage. ie six,  6 volt batteries equal a 36 volt golf cart.

Electric vehicles most commonly associated with system voltage: EZGO  36 volt,  EZGO RXV 48 volt, Western 42 volt, Yamaha 36 volt & 48 volt, Club Car 48 volt, GEM Car & Ford Think 72 volt system.

Crown golf cart battery Crown Battery began in 1926 and are in our opinion, the longest lasting Golf Cart Battery you can buy. Crown deep cycle batteries have the thickest plates in the industry for longer life, with 10-20% more Lead than ANY other manufacturer. This is the standard (GC-2/T-105 size) 220 amp-hour golf car sized battery. Equivalent to any 6 volt golf cart type battery (but better). The Crown CR-220 deep cycle batteries come with dual terminals, so you can use standard SAE automotive connectors or bolt on connections.

Rated Best Golf Cart Battery San Diego and Can Last 5-6 Years With Regular Maintenance and Care

Crown golf cart batteryPrice for Crown CR 220 6 Volt $120 ea with exchange*

*Unit Price for 6 volt Crown Golf Cart Battery for Sale: $120 ea* with exchange
 (Cores are required to void core charge of $15) Crown Battery CR-220

Rate of Discharge: 412 min. @ 25 Amps | 110 min @ 75 Amps
Amp Hours {AH}: 220 AH  at 20 Hour Rate
Weight: 60 Lbs
Dimensions {L x W x H} 10.25 in x 7.06 in x 10.94 in
50% DOD #Cycles: 1200 Cycles

Crown golf cart battery Crown CR 235 San Diego
Rated Best 6 Volt Battery for RV Can Last 5-6 Years With Regular Maintenance and Care

Crown golf cart battery Price for Crown CR 235 6 Volt $130 ea with exchange*

*Unit Price for Crown 6 volt Battery for RV for Sale: $130 ea* with exchange
 (Cores are required to void core charge of $15) CrownCR-235

Rate of Discharge: 125 min @ 75 Amps
Amp Hours {AH}: 235 AH  at 20 Hour Rate
Weight: 63 Lbs
Dimensions {L x W x H} 10.25 in x 7.06 in x 10.94 in
Cycle Life: 750

Crown golf cart battery Crown CR 260 San Diego
Rated Best High Capacity Golf Cart Battery San Diego and Can Last 5-6 Years With Regular Maintenance and Care

Crown golf cart battery Price for Crown CR 260 6 Volt $157 ea with exchange*

*Unit Price for Crown Golf Cart Battery San Diego for Sale: $157 ea* with exchange
 (Cores are required to void core charge of $15) Crown 6 Volt Battery

Rate of Discharge: 140 min @ 75 Amps
Amp Hours {AH}: 260 AH  at 20 Hour Rate
Weight: 65 Lbs
Dimensions {L x W x H} 10.25 in x 7.06 in x 11.63 in
Cycle Life: 750

Crown golf cart battery Crown CR 205 BEST VALUE! Least Expensive Golf Cart Battery San Diego and Will Last the Longer than Costco or Trojan 6 volt Golf Cart Battery
Rated Better Golf Cart Battery San Diego and Can Last 4-5 Years With Regular Maintenance and Care

Crown golf cart battery Price for Crown CR 205 6 Volt $95 ea with exchange*

*Unit Price for 6 volt Crown Golf Cart Batteries for Sale: $95 ea* with exchange
 (Cores are required to void core charge of $15) Crown Battery CR-205

Rate of Discharge: 105 min @ 75 Amps
Amp Hours {AH}: 205 AH  at 20 Hour Rate
Weight: 60 Lbs
Dimensions {L x W x H} 10.25 in x 7.06 in x 10.94 in
Cycle Life: N/A

Trojan golf cart battery Trojan Battery history: George Godber & Carl Speer founded Trojan Battery Company and in 1952 invented the electric golf car battery. Trojan Manufacturing Features and Benefits:

  • Do not use high speed production process for plate mfg.
  • Produce Cast grids with heavy Wire and Frame design.
  • Maxguard Advanced Design Separator
  • Use proprietary Alpha Paste on each Grid
  • Rated Best EZGO Golf Cart Batteries and Can Last 5-6 Years With Regular Maintenance and Care

Trojan golf cart battery Call Us – On Sale! Price for Trojan T-105 6 Volt $125 ea with exchange*
*Unit Price for 6 volt Trojan T-105 Batteries for Sale: $125 ea* with exchange
(Cores are required to void core charge of $15)

Rate of Discharge: 447 min. @ 25 Amps | 115 min @ 75 Amps
Amp Hours {AH}: 225 AH  at 20 Hour Rate
Weight: 62 Lbs
Dimensions {L x W x H} 10 ⅜ in x 7 ⅛ in x 10 ⅞ in
Cycle Life: 750 Cycles

Trojan Battery Charging and Maintenance Guide

Inexpensive 6 Volt Battery for RV $80 ea* with exchange
Call Today to Speak to a Technician (619) 448-5323

 

Trojan golf cart battery Trojan OEM Golf Cart Battery San Diego–  Trojan Pacer Battery  210 amp hour

Trojan 6 volt Pacer Deep Cycle Battery is manufactured by Trojan as an OEM battery. It is not as robust as the T-105 but is a good value for $80 ea and a better value than the Costco 6 volt battery
* Trojan Pacer 6 volt deep cycle battery price : $80 ea *(Cores are required to void core charge of $15)
Trojan golf cart batteryFree Local Delivery in San Diego for 2 or More

Trojan 6 volt Deep Cycle Pacer Battery for Golf Cart Battery San Diego
*Unit Price for Trojan Pacer 6 volt Battery for Sale: $80 ea* with exchange
 (Cores are required to void core charge of $15) Trojan 6 Volt Battery for RV

US golf cart battery US Battery history – Since 1928, US Battery has been building flooded lead acid deep cycle batteries.  Family owned company that manufactures batteries in the USA. Manufacturing Features and Benefits:

  • Addition of synthetic TTBLS (tetrabasic lead sulfate)
  • Increased initial capactiy
  • Higher peak capacity
  • Decreased plate shedding from deep cycling
  • Rated Better EZGO EZGO Golf Cart Battery Can Last 4-5 Years With Regular Maintenance and Care

US golf cart batteryPrice for US Battery US2200XC 6 Volt $115 ea with exchange*

*Unit Price for 6 volt US Battery EZGO Golf Cart Batteries for Sale: $115 ea* with exchange
 (Cores are required to void core charge of $15)

Rate of Discharge: 474 min. @ 25 Amps | 122 min @ 75 Amps
Amp Hours {AH}: 232 AH  at 20 Hour Rate
Weight: 62 Lbs
Dimensions {L x W x H} 10 ⅜ in x 7 ⅕ in x 10 ⅝ in
50% DOD #Cycles: 1150 Cycles

 

Golf Cart Battery San Diego– 8 volt Golf Cart Batteries for Sale
8 Volt Golf Cart Batteries are for 48 volt Golf Carts

Six 8 volt golf cart batteries are wired in series to create a 48 volt system

Crown golf cart battery Rated Best 8 Volt Golf Cart Battery San Diego and Can Last 5-6 Years With Regular Maintenance and Care

Crown golf cart battery Price for Crown CR 150 8 Volt $130 ea with exchange*

*Unit Price for 8 volt Crown Golf Cart Battery for Sale: $130 ea* with exchange
 (Cores are required to void core charge of $15) Crown 8 Volt Battery CR-150

Rate of Discharge:  90 min @ 56 Amps
Amp Hours {AH}: 150 AH  at 20 Hour Rate
Weight: 60 Lbs
Dimensions {L x W x H} 10.31 in x 7.06 in x 10.82 in
50% DOD #Cycles: 1200 Cycles

Trojan Battery for 48 Volt Golf Carts RXV & Precedent

#1 Choice 6 volt Battery for 48 volt Golf Cart, Trojan Deep Cycle Golf Cart Battery – 12 volt Trojan T-1275 150 amp hour

Trojan golf cart battery

Trojan T-1275 Golf Cart Battery

Trojan golf cart battery

Fits Precedent, RXV, Yamaha 48 volt models

Trojan Battery history: George Godber & Carl Speer founded Trojan Battery Company and in 1952 invented the electric golf car battery. Trojan Manufacturing Features and Benefits:

  • Do not use high speed production process for plate mfg.
  • Produce Cast grids with heavy Wire and Frame design.
  • Maxguard Advanced Design Separator
  • Use proprietary Alpha Paste on each Grid.
  • Longer cycle life
  • Reduced water consumption
  • Less battery maintenance

*Price for 12 volt Trojan T-1275 Batteries for Sale: $185 ea*(Cores are required to void core  charge of $15)

golf cart battery

For Battery Delivery and Installation Click Here

De-Sulfating Golf Cart Batteries

The chemical interaction that produces electricity from a golf cart battery also produces lead sulfate. When a battery is fully charged all the sulfuric acid molecules are bonded to water molecules (H2) to create battery acid or battery electrolyte Sulfuric Acid (H2SO4). When a battery delivers an electrical current the sulfuric acid molecules break their bonds with the water and combine with the lead dioxide (PbO2) in the plates creating a new chemical compound known as lead sulfate.
If the golf cart battery is left in a state of discharge, damage occurs when the lead sulfate compound is not reversed by recharging.


Trojan golf cart battery